CV Boot came off

[Leeboy8500]

My CV boot came off font passenger while off-roading yesterday. Hopefully the joint isn’t cooked, but it didn’t sound good by the time I limped it back to the highway for a tow.
Is there anything that can be done to prevent / protect against this happening again?

Sponsored

 

[GI_Jo_Nathan]

Just curious what's your setup? Stock suspension or some sort of lift?

 

[Leeboy8500]

Just curious what's your setup? Stock suspension or some sort of lift?

Just curious what's your setup? Stock suspension or some sort of lift?

Badlands SAS with HOSS 3.0. I have the 2.5” Zone Offroad levelling kit with OEM tires and wheels.

 

[Ratfink33]

Badlands SAS with HOSS 3.0. I have the 2.5” Zone Offroad levelling kit with OEM tires and wheels.

Does that kit come with new upper control arms?

 

[contented]

From your description, it will likely need replaced. If you’re leveled/lifted 2.5” above SAS, the likely cause is your cv angles are too great. Can you post a photo looking straight in, parallel with the ground showing cv and tie rod angles.

 

[AB8DT]

Running 37" Toyo Open Country MT with Icon Stage 2 lift I had the same issue coming back from Windrock TN with the boot sliding off and getting debris in side the CV. I had to have both CV shafts replaced under warranty. To avoid this in the future I picked up inner & outer high angle boots from Poly Performance.

https://www.polyperformance.com/rcv-high-temp-orange-boot-for-front-ifs-axles

 

[Brian_B]

I had a stick come up from the mud and poke one of mine off. Was annoying. It started clicking a day or two later.

I know folks have replaced just the boot. From what I recall, the OEM boot was like $100 (try MB3Z-3B436-B), and you could buy the entire OEM CV for about $150 and not have to mess with cleanup, grease, or the possibility that it was damaged and just isn't presenting yet.

Some people have found aftermarket boots to fit for much cheaper - I don't know of one though.

-- I just went to look at CV prices, and appears they have went up significantly - running around $350 right now. You can get the Ford Performance Painted set ($400) for about $50 more than a single CV.

As far as protecting it - CV angle as everyone here has suggested plays into that. Beyond that - ... not really. Maybe LCA skids might help if it was from something exterior (like mine was), but even that's not a sure thing.

Sponsored